TM 10-4130-237-14
Para
5 - 2
5 - 3
5 - 4
5 - 5
5 - 6
5 - 7
5 - 8
5 - 9
Water System Leak Test. . . . . . . . . . . . . . .
Water Pump Repair . . . . . . . . . . . . . . . . . .
Evaporator Replacement . . . . . . . . . . . . . .
5-17
5-18
5-19
5-20
5-21
5-22
5-23
5-24
5-25
5-26
5 - 10
5 - 11
5 - 12
5 - 13
5 - 14
5 - 15
5 - 16
5 - 27
5 - 28
CHAPTER 5
DIRECT SUPPORT MAINTENANCE
Section L DIRECT SUPPORT TROUBLESHOOTING
Para
General . . . . . . . . . . . . . . . . . . . . . . . . . . . . 5-1
Section II. DIRECT SUPPORT MAINTENANCE PROCEDURES
General . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Carburetor Repair . . . . . . . . . . . . . . . . . . .
Starter Repair . . . . . . . . . . . . . . . . . . . . . . .
Cylinder Heads Replacement . . . . . . . .
Cylinder Block Assembly Replacement .
Refrigeration System Leak-Test . . . . . .
Refrigeration System Pressure Test . . .
Refrigeration System Service . . . . . . . .
Compressor Suction Hose Replacement ..
Compressor Discharge Hose Replacement
High Pressure Switch Replacement
Low Pressure Switch Replacement . . .
Condenser Replacement . . . . . . . . . . . . . .
Pressure Relief Valve Replacement . . . . .
Expansion Valve Replacement . . . . . . . . .
Compressor Replacement . . . . . . . . . . .
Compressor Repair . . . . . . . . . . . . . . . . . .
Filter Drier Replacement . . . . . . . . . . . .
Relief Valve Replacement . . . . . . . . . . . .
Thermostatic Valve Replacement . . . . .
Thermostatic Valve Repair . . . . . . . . . . .
Ball Valve Assembly Replacement . . .
Low Temperature Thermal Switch
Replacement . . . . . . . . . . . . . . . . . . . . . .
Trailer Mounting Kit Installation . . . . .
Modified Trailer Mounting Kit
Installation . . . . . . . . . . . . . . 5-29
Section I. TROUBLESHOOTING
5-1.
GENERAL. Table 5-1, Troubleshooting, lists common malfunctions which may be found during normal op-
eration or during an inspection, check procedure, or scheduled testing. Perform the tests/inspections and corrective actions
in order listed. This manual cannot list all malfunctions that may occur or list all tests/inspections and corrective actions.
If a malfunction occurs that is not listed or covered in corrective action, notify your supervisor.
5-1
