TM 5-5430-212-13&P
(3)
Locate the anchor points as shown in Figure 2-2 and install as shown in Fig. 2-3 or 2-3A. For Model 5,000
gallon only, re-check the area for sharp objects. If the surface is rough and jagged, it will be necessary to
place plywood or a tarpaulin down for the tank to rest upon.
(4)
Attach the ratchet take-up mechanism to each anchor point by using a shackle between the eye-bolt and
delta ring on the ratchet take-up mechanism.
(5)
Lay the tie-down straps crosswise to the length of the semi-trailer bed as shown in Fig. 2-3 or 2-3A. Make
sure the belts are centered accurately between the eyebolts. Let the remaining portion of the belts lay over
the side of the trailer. Care should be taken to insure that each strap is not twisted and is laying flat. The
area is now prepared for tank unfolding.
b.
Installation of Tank on Trailer Bed
(1)
Using a lifting device, such as a forklift or crane, take hold of the sling by its lift straps (7, Fig. 2-1) and place
the tank on the semi-trailer in such a manner that the tank will unroll towards the rear of the trailer. The tank
ends should be near or touching the trailer bulkhead.
(2)
Remove the straps from the buckles on the sling assembly and unroll and unfold the tank over the tie-down
straps. Visually inspect tank while unrolling. Position it so that when it is full, the ends or sidewalls of the
tank will not rub against the forward bulkhead or hang over the sides of the trailer. Remove the sling
assembly from under the tank and place it in the trailer stowage compartment.
2-4.
Inspecting and Servicing the Equipment
a.
Tank
(1)
Inspect tank body for any punctures or tears.
(2)
Inspect the fittings and components for evidence of damage or missing bolts or gaskets.
b.
Tie-down Kit
(1)
Inspect tie-down assembly for frays, tears or cuts.
(2)
Inspect eyebolt for thread mutilation and insure that eyebolt, lockwasher, and nut are securely fastened to
retainer plates.
(3)
Inspect ratchet take-up, shackle, and other tie-down hardware for damage.
c.
Accessories. Inspect sling, lift straps, and duffle bag for frays, punctures, and tears.
Change 4
2-4
