TM 10-4610-243-13CHAPTER 3OPERATOR MAINTENANCE INSTRUCTIONSSection ILubrication Instructions ................................................................................................3-1Section IIOperator Troubleshooting .............................................................................................3-13-1Introduction .....................................................................................................................3-13-2Malfunction Index.............................................................................................................3-23-3Troubleshooting Table......................................................................................................3-2Section IIIOperator Maintenance Procedures..............................................................................3-263-4Component Replacement.................................................................................................3-263-5Quick Disconnect Coupling Repair ...................................................................................3-28Section I. LUBRICATION INSTRUCTIONSLubrication of the 800K Water Storage and Distribution System is limited to the 350 gpm and 125 gpm pumps.Lubricate this equipment in accordance with the applicable technical manual.Refer to the applicable TMfor lubrication requirements on the 350 gpm pumps.Refer to the applicable TM for lubrication requirements on the 125 gpm pumpsSection II. OPERATOR TROUBLESHOOTING3-1. INTRODUCTION.a. The troubleshooting table lists the common malfunctions which you may find during operation of the watersystem. You should perform the tests, inspections and corrective actions in the order they appear in the table.b.This table cannot list all the malfunctions that may occur, all the tests or inspections needed to find the fault, orall the corrective actions needed to correct the fault. If the equipment malfunction is not listed or actions listeddo not correct the fault, notify your supervisor.c.Refer to the applicable TM for troubleshooting malfunctions on the 350 gpm pumps.d.Refer to the applicable TM for troubleshooting malfunctions on the 125 gpm pumpse.Refer to the applicable T'M for troubleshooting malfunctions on the hypochlorination units.f.Refer to the applicable TM for troubleshooting malfunctions on the 50K collapsible fabric tanks.3-1
Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business
