TM 10-4320-346-12&PCHAPTER 3OPERATOR MAINTENANCE INSTRUCTIONSSection I. LUBRICATION INSTRUCTIONS3-1. GENERAL. No lubrication is required for the FAWPSS itself, however, the pump and engine assembly used withthe FAWPSS does require lubrication. Refer to the pump and engine assembly technical manual for the for properlubrication procedures.Section II. OPERATOR TROUBLESHOOTING PROCEDURES3-2. INTRODUCTION.a.This section contains troubleshooting information for locating and correcting most of the operating troubleswhich may develop in the FAWPSS. Each malfunction for an individual component, unit, or system is followed by a listof tests or inspections which will help you to determine corrective actions to take. You should perform thetests/inspections and corrective actions in the order listed.b.This manual cannot list all malfunctions that may occur, nor all tests or inspections and corrective actions. Ifa malfunction is not listed, or is not corrected by listed corrective actions, notify your supervisor.c.Table 3-1 lists the common malfunctions which you may find during the operation or maintenance of theFAWPSS or its components. You should perform the tests/inspections and corrective actions in the order listed.3-3. MALFUNCTION INDEX.MALFUNCTION .......................................................................................................................... PAGE NO.PUMP AND ENGINE ASSEMBLYPump and engine assembly will not start .............................................................................................. 3-2Pump and engine assembly starts, but will not pump rated capacity ..................................................... 3-2Pump and engine assembly starts, but water cannot be dispensed ....................................................... 3-2HOSE ASSEMBLIESHose assembly leaks............................................................................................................................ 3-3OTHER FAWPSS COMPONENTSLeaks occur at joints of components ..................................................................................................... 3-3Components leak at places other than joints......................................................................................... 3-43-4. OPERATOR TROUBLESHOOTING TABLE. Refer to Table 3-1 for the operator troubleshooting proceduresauthorized for the FAWPSS.3-1
Integrated Publishing, Inc. - A (SDVOSB) Service Disabled Veteran Owned Small Business
